Spicy Brisket Sandwich Recipes

Steps:

• Cook onions in hot oil until caramelized. Add jalapeño. Add brisket and BBQ sauce, stirring, until incorporated and warm. Gather onions, jalapeños and brisket into a mound, then place Gouda on top and cover until cheese melts. Toast hoagie roll on hot griddle until crisp. Place all of the filling on hoagie roll.
• For the Smokehouse brisket rub: Combine the mesquite powder, brown sugar, smoked paprika, salt, au jus powder, granulated sugar, chili powder, cumin, garlic powder, mustard powder, onion powder and black pepper in a large bowl until thoroughly incorporated.
• For the brisket: Preheat oven to 350 degrees F.
• Trim excess fat from the brisket, leaving a good layer for flavor. Spread a thick layer of rub over entire brisket in a heavy-duty baking pan, and work rub into the layer of fat. Add liquid smoke and 1/2 cup water, then cover tightly with aluminum foil. Braise in oven until tender, about 4 hours.
• To a large heavy-duty cooking pot over low heat, add, in order and whisking vigorously until incorporated, the coffee, brown sugar, molasses, Worcestershire, vinegar, honey, hot sauce, ketchup, liquid smoke, mustard, garlic powder, onion powder, cayenne, chili powder, mustard flour and black pepper. Continue to cook on low heat, stirring every 5 minutes, for 30 minutes.

Steps:

• For the BBQ rub: Mix together smoked paprika, brown sugar, chili powder, salt, pepper, granulated garlic and onion powder in a bowl. Set aside.
• For the brisket: Trim excess fat from the outside of the brisket, keeping about 1/2-inch layer of fat on.
• Chop up excess fat and place it in a pot with 1 cup of the vegetable oil. Cook over medium-low heat, stirring occasionally, until the fat starts to brown, 10 to 15 minutes. Turn off heat and let cool, then strain to remove all the fat chunks. Set aside.
• Rub some of the remaining 1/4 vegetable oil all around the outside of the brisket. Rub brisket liberally with 3/4 cup BBQ rub (save remainder for another use). Rub the rest of the vegetable oil on top of the BBQ rub. (When putting rub on meat, just remember, "oil, rub, oil.")
• Let the brisket rest, covered and refrigerated, overnight. (If you are in a hurry, you could let it sit in the fridge for a couple hours and it should turn out okay.)
• Heat an outdoor grill to 350 degrees F. Preheat an oven to 200 degrees F.
• Sear the outside of the meat on all sides on the grill. Since we are not using a smoker, it is important to get some open flame action to caramelize the outside of the meat so we get some smoke flavor. Cover the meat with foil or thick butcher paper and place in a hotel pan.
• Transfer to the oven and roast for 12 hours or overnight. Let cool.
• For the coffee BBQ sauce: Melt the butter in a saucepot, then add garlic and shallots. Cook, stirring, until they start to caramelize. Add the BBQ sauce, coffee and bay leaf and simmer on medium-low heat, stirring frequently, for about 30 minutes. Let cool, remove the bay leaf and puree in a blender (optional). Set aside.
• Ready to make the sandwiches! Slice the brisket about 1/4-inch-thick and place in a large enough saute pan that each piece can be flat in the pan in a single layer. Add just enough BBQ sauce to come about halfway up the side of the meat. Heat the pan on medium to high heat. Meanwhile, split the burger buns. Toast the buns and add the melted butter to the insides.
• Heat the oil in a deep-fryer to 350 degrees F.
• Fry shoestring potatoes until they start to turn golden brown, then add the sliced jalapenos to the fryer and continue frying until the fries are golden and jalapenos are crispy but still bright green, 1 to 2 minutes. Let drain, then place in a bowl and season with salt and pepper. Set aside.
• Meanwhile, pay attention to the brisket in the pan. Turn each piece over on the other side with tongs and continue searing.
• Pour about 1/4 cup beef fat into another saute pan. Heat on medium-high heat and add the sliced onions. Cook the onions down until they start to get a dark caramelization-thing going on, then add salt and pepper to taste. Turn off heat, drain excess oil and set aside. At this point the brisket should be looking good. You want there to be a deep-dark crust forming on the outside.
• Time to assemble! Place buns on a tray, lay your Cheddar down on the bottom, add the BBQ brisket on top, beef fat onions on top of the brisket, jalapeno shoestrings on top of the onions, put on your bun lids...DONE!

Steps:

• Mix all of the dry rub ingredients together in a small bowl. Dab the brisket dry with paper towels. Coat the brisket all over with the dry rub. Make a mesquite fire inside the oven of a smoker. A combination of charcoal and mesquite chips (wet) is fine. Put the brisket on the right side of the grates in the main oven of the smoker. Damp down the fire. Leave the brisket to smoke until the fire burns out.
• In the meantime, In a large skillet, saute the bacon and vegetables until they are moist. Put them into a 6-inch deep, full-sized, hotel pan. Add the brisket, beer, vinegar, Worcestershire and garlic. Cover the pan with a sheet of parchment paper and tightly cover with a sheet of heavy foil. Cook overnight in a 250 degree F oven.
• Cut the brisket into chunks and serve on a whole-wheat buns with the BBQ sauce, sliced red onion and pickles.
• Heat some oil (about 1/4 cup or less) in a heavy-bottomed pan over medium heat. Add the shallots and saute for a couple of minutes. Add the remaining ingredients and bring to slow boil - be careful not to burn. Cook on ultra low heat for about 8 hours (1.5 in prep room hot plate). Cool. Add the sauce to a food processor and blend to combine. Dilute with brisket pan juice before using.

Steps:

• Season the beef with the black pepper and garlic powder and place into a 3-quart shallow baking dish. Stir the picante sauce, brown sugar and Worcestershire in a small bowl. Spread the picante sauce mixture over the beef. Cover the dish and refrigerate overnight.
• Bake, covered, at 300 degrees F for 4 1/2 hours or until the beef is fork-tender. Slice or shred the beef. Divide the beef and sauce among the rolls.

Steps:

• Preheat the oven to 200 degrees F.
• For the homemade dry rub:
• On a parchment paper-lined baking tray, put the garlic, ginger, shallots, and onions and bake in the oven 4 hours, or until dried. Using a food processor, reduce into a powder with the brown sugar, salt, and pepper. Set aside.
• Coat the brisket with the spice mixture. Cover and keep in the refrigerator overnight to marinate and flavor the meat.
• For the apple barbecue sauce:
• In a large bowl, mix together the onion, chipotle pepper, garlic, ketchup, honey, molasses, soy sauce, Worcestershire sauce, lemon juice, salt, and pepper, to taste.
• Preheat the oven to 350 degrees F.
• Place the brisket, fat-side up, into a heavy baking pan just large enough to hold it, and pour sauce over it. Cover tightly and bake for 4 hours or until fork-tender.
• Transfer the brisket to a cutting board and keep warm.
• Strain and pour the sauce in a stockpot and let reduce for about 10 minutes on medium high heat until thick. Remove excess fat.
• Cut the meat with a sharp knife against grain, to desired thickness.
• To assemble:
• Garnish onion buns with the meat, sauce, tomatoes, lettuce and top with deep-fried onion rings.
• Cook's Notes: You can buy dried onions and garlic from grocery stores instead of preparing it. The apple barbecue sauce is a recipe on its own and very versatile. It can be used as a dip, as a sauce or as a glaze for other meats like chicken, pork, etc.
• The brisket can be served on its own and served with mashed potatoes and vegetables.
• Brisket can also be sliced and frozen for later use.
• Make the brisket the day before and reheat for best flavor.

Steps:

• Sprinkle brisket with seasoned salt and pepper. In a Dutch oven, brown meat in oil on both sides. Remove and keep warm. In the same pan, saute onions and garlic until tender. Return brisket to pan. , Combine broth, chili sauce, brown sugar, vinegar, chili powder and bay leaves; pour over meat. Bring to a boil. Reduce heat; cover and simmer for 2-1/2 to 3 hours or until meat is tender., Remove brisket to a serving platter. Skim fat from cooking juices; discard bay leaves. Combine flour and cold water until smooth; stir into pan. Bring to a boil; cook and stir for 2 minutes or until thickened. Thinly slice meat across the grain; serve with sauce.